RESISTANCE-TEMPERATURE CHARACTERISTIC: (RTC)
The difference between the total resistance values measured at a reference temperature of 25°C and the specified test temperature expressed as a percent of the Total Resistance.
Where:
R1 = Resistance at reference temperature (25°C) in ohms
R2 = Resistance at the test temperature in ohms

Principle of Trimmer Potentiomerets

A fixed resistor with a mechanism to change resistance construct a trimmer potentiometers. The principle is with the changing of resistive element length according a wiper sliding, the resistance will be changed. Use this method, with same sectional area, the resistance can be changed relative to resistive element length, and products can be manufactured in low cost.



            R: Resistance [Ω] 
            ρ: Resistivity [Ω/m] 
            L: Resistive element length [m] 
            S: Resistive element sectional area [m2]

  • The position of contact point decide the length of resistive element.
    Resistance between No.1 and No.2 (R12) will become higher if contact point become closer to No.3.
  • For easy introduction, we drew the resistive element like a rectangular solid. Actually, almost resistive element is round shape 
    (U - shaped) .So the track of wiper is circle, and resistance is decide by the angle of wiper. 

Change in resistance of Trimmer Potentiometers

There is the relationship between wiper position (angle) and resistance in below figure.

The output wave is besed on below conditions.
Resistive element is round shape (U - shaped) /Single - turn/No whirl - stop.

Construction
Single - turn, no whirl - stop typ    The relationship between wiper position (angle) and resistance


Feature of Trimmer Potentiometers

By using trimmer potentiometers, it is no problem to set surrounding circuit constant roughly.
Would you please use trimmer potentiometers if it is difficult to decided on a resistance value in your circuit. You can design your circuit roughly and quickly as the result.

The fundamental electrical properties of multilayer ceramic capacitors are as follows:

Polarity: Multilayer ceramic capacitors are not polar, and may be used with DC voltage applied in either direction.

Rated Voltage: This term refers to the maximum con tinuous DC working voltage permissible across the entire operating temperature range. Multilayer ceramic capacitors are not extremely sensitive to voltage, and brief applications of voltage above rated will not result in immediate failure. However, reliability will be reduced by exposure to sustained voltages above rated.

Like all other practical capacitors, multilayer ceramic capacitors also have resistance and inductance. A simplified schematic for the equivalent circuit is shown in Figure 1. Other significant electrical characteristics resulting from these additional properties are as follows:

Impedance: Since the parallel resistance (Rp) normally very high, the total impedance of the capacitor is :

The variation of a capacitor’s impedance with frequency determines its effectiveness in many applications.

Contact us

Tel: (86) 769 8118 8110
Tel: (852) 8106 7033
Fax: (852) 8106 7099
E-mail: info@kingtronics.com
Skype: kingtronics.sales
MSN: kingtronics-sales@hotmail.com
Web: www.Kingtronics.com

About

Kingtronics International Company was established in 1995 located in Dongguan City of China to handle all sales & marketing for factories located in Chengdu, Sichuan and Zhaoqing, Guangdong, China. In 1990, we established the first factory to produce trimming potentiometer and in 1999 we built up new factory in Zhao Qing, Guangdong. Now with around 850 workers, Kingtronics produce trimming potentiometers, dipped tantalum capacitors, multilayer ceramic capacitors, and diode & bridge rectifier. We sell good quality under our brand Kingtronics, and Kt, King, Kingtronics are our three trademarks. All our products are RoHS compliant, and our bridge rectifier have UL approval. Please visit our Products page, you could please download all our PDF datasheet and find cross reference for our Trimming Potentiometer and capacitors.

Tantalum and Ceramic Capacitors Cross Reference ↓ Download
Diodes & Rectifiers List(PDF: 97KB) ↓ Download
Trimming Potentiometer Cross Reference ↓Download

Meet Kingtronics in Moscow soon
electronicAsia-2019
electronicAsia-2019
Convention and Exhibition Centre,HongKong
Date: 13-16 October, 2019
Booth No.: 5G-C26

Meet Kingtronics in Munich soon
electronica-2020
Electronica-2020
New Munich Trade Fair Centre, Germany
Date: 10-13 November, 2020
Booth No.: To be advised

Archives

Calendar

<< 2019-10 >>

Sun

Mon

Tue

Wed

Thu

Fri

Sat

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31